植物乳杆菌发酵提取未成熟琯溪蜜柚果实果胶工艺优化
作者:
作者单位:

(1. 集美大学海洋食品与生物工程学院,福建 厦门 361021;2. 福建省食品微生物与酶工程重点实验室,福建 厦门 361021;3. 厦门市食品生物工程技术研究中心,福建 厦门 361021)

作者简介:

丁红霞,女,集美大学在读硕士研究生。

通讯作者:

杨远帆(1971—),女,集美大学教授,博士。E-mail: yuanfan@jmu.edu.cn

中图分类号:

基金项目:

福建省科技厅引导性项目(编号:2021N0015)


Optimization of pectin extraction from immature fruits of Guanxi pomelo by Lactobacillus plantarum fermentation
Author:
Affiliation:

(1. College of Ocean Food and Biological Engineering, Jimei University, Xiamen, Fujian 361021, China; 2. Fujian Provincial Key Laboratory of Food Microbiology and Enzyme Engineering, Xiamen, Fujian 361021, China; 3. Research Center of Food Biotechnology of Xiamen City, Xiamen, Fujian 361021, China)

Fund Project:

  • 摘要
  • |
  • 图/表
  • |
  • 访问统计
  • |
  • 参考文献
  • |
  • 相似文献
  • |
  • 引证文献
  • |
  • 资源附件
  • |
  • 文章评论
    摘要:

    目的:利用植物乳杆菌发酵未成熟琯溪蜜柚果实提取果胶,并分析植物乳杆菌发酵提取果胶的性质。方法:以果胶提取率为指标,采用正交试验优化植物乳杆菌发酵未成熟琯溪蜜柚果实提取果胶的工艺条件,并测定果胶的半乳糖醛酸含量、酯化度、蛋白质、持水性、持油性、乳化活性以及乳化稳定性。结果:植物乳杆菌发酵未成熟琯溪蜜柚果实提取果胶的最佳工艺条件为发酵温度37 ℃、植物乳杆菌发酵接种量14%、液料比25∶1 (mL/g)、发酵时间12 h。此条件下未成熟琯溪蜜柚果胶提取率为11.60%;果胶的半乳糖醛酸含量、酯化度、蛋白质、持水性、持油性、乳化活性以及乳化稳定性分别为26.13%、68.58%、1.57%、0.53 g/g、7.01 g/g、14.33%和33%。结论:植物乳杆菌发酵提取的果胶提取率与酸法工艺的相似,所得果胶为高酯化度果胶,且应用性质良好。

    Abstract:

    Objective: This study aimed to optimize the pectin extraction yield from immature fruits of Guanxi pomelo by L. plantarum fermentation and analysis of the properties of pectin extracted by L.s plantarum fermentation. Methods: Taking the extraction yield of pectin as the index, orthogonal test was used to optimize the process conditions of fermentation of immature fruits of Guanxi pomelo by L. plantarum, and the content of galacturonic acid, degree of esterification, protein, water-holding capacity, oil-holding capacity, emulsifying activity and emulsion stability of pectin were determined. Results: The optimal conditions for fermentation of immature fruits of Guanxi pomelo by L. plantarum were as follows: fermentation temperature of 37 ℃, L. plantarum fermentation inoculum of 14%, liquid-solid ratio of 25∶1 (mL/g), and fermentation time of 12 h. Under the control of these conditions, the extraction yield of pectin was 11.60%, and the content of galacturonic acid; the degree of esterification, protein, water-holding capacity, oil-holding capacity, emulsifying activity and emulsion stabilities were about 26.13%, 68.58%, 0.53 g/g, 7.01 g/g, 14.33% and 33%, respectively. Conclusion: The extraction yield of pectin extracted by fermentation of L. plantarum was similar to that of the acid process, and the obtained pectin was highly esterified pectin with good application properties.

    参考文献
    相似文献
    引证文献
引用本文

丁红霞,杨远帆,黄淑安,等.植物乳杆菌发酵提取未成熟琯溪蜜柚果实果胶工艺优化[J].食品与机械,2024,41(2):192-196.
DING Hongxia, YANG Yuanfan, HUANG Shuan, et al. Optimization of pectin extraction from immature fruits of Guanxi pomelo by Lactobacillus plantarum fermentation[J]. Food & Machinery,2024,41(2):192-196.

复制
分享
文章指标
  • 点击次数:
  • 下载次数:
  • HTML阅读次数:
  • 引用次数:
历史
  • 收稿日期:2023-04-26
  • 最后修改日期:
  • 录用日期:
  • 在线发布日期: 2024-03-27
  • 出版日期:
湘CP备05003881

邮政编码 :410114

联系地址:湖南省长沙市天心区万家丽南路二段960号

投稿邮箱:foodmm@ifoodmm.com

联系电话:0731-85258200